怎樣判斷制氮機的運行狀況良好

判斷制氮機在運行當中是否良好，可以根據下面的露點來分析。靈活應用，如果還是有疑問，可以聯系制氮機廠家技術人員查看。

Judging whether the nitrogen generator is in good operation can be analyzed according to the following dew point. Flexible application, if you still have questions, you can contact the technical personnel of the nitrogen generator manufacturer to check.

1、電源指示燈亮，左吸、均壓、右吸指示燈循環發亮指示制氮流程。

1. The power indicator light is on, and the indicator lights of left suction, voltage equalizing and right suction are on circularly to indicate the process of nitrogen production.

2、左吸指示燈亮時，左吸附塔壓力由均壓時平衡壓力逐漸升至最高，制氮機同時右吸附塔壓力由均壓時平衡壓力逐漸降為零。均壓指示燈亮時，左右吸附塔壓力降一升一降逐漸達到兩者平衡。

2. When the left suction indicator light is on, the pressure of the left adsorption tower gradually rises to the highest value from the equilibrium pressure during pressure equalization, and the pressure of the right adsorption tower of the nitrogen generator gradually drops to zero from the equilibrium pressure when the pressure is equalized. When the pressure equalizing indicator light is on, the pressure drop of the left and right adsorption towers increases and decreases gradually to reach the balance between the two.

3、右吸指示燈亮時，右吸附塔壓力由均壓時平衡壓力逐漸升至最高，同時左吸附塔壓力由均壓時平衡壓力逐漸降為零。

3. When the indicator light of the right adsorption tower is on, the pressure of the right adsorption tower gradually rises to the highest value from the equilibrium pressure during the pressure equalization, and the pressure of the left adsorption tower gradually drops to zero from the equilibrium pressure when the pressure is equalized.

4、制氮機氮氣出口壓力指示為正常用氣壓力，使用時壓力會(huì )有稍微波動，但變化不應過大。

4. The nitrogen outlet pressure of the nitrogen generator is indicated as the normal gas pressure. The pressure will fluctuate slightly during use, but the change should not be too large.

5、力量計指示應基本穩定，波動不應過大，流量計的示值不應大于制氮機設備的額定產氣量。

5. The indication of the dynamometer should be basically stable and the fluctuation should not be too large. The indication value of the flowmeter should not be greater than the rated gas production of the nitrogen generator.

6、制氮機測氧儀示值應不小于制氮設備的額定純度，也許會(huì )有少許波動，但不應波動過大。

6. The indication value of oxygen meter of nitrogen generator should not be less than the rated purity of nitrogen generating equipment. There may be a little fluctuation, but it should not be too large.

這些事為了告訴大家制氮機運行狀態良好的幾個特狀，對于使用方來說，山東制氮機建議可以聯系廠家技術人員查看。

In order to tell you the characteristics of the nitrogen generator running well, for the user, Shandong nitrogen generator can contact the manufacturer's technical personnel to check.